Kitchen Gourmet WM-6105 Disassembly

소개

This is a disassembly guide for the Kitchen Gourmet Electric Hot Pot Model No. WM-6105 that allows you to access all of the components without permanently damaging any of them. This disassembly only requires use of a screwdriver. Further disassembly to replace individual components would require soldering, which is not covered in this guide.

필요한 것

1 단계 Water Heater

Kitchen Gourmet WM-6105 Disassembly, Water Heater: 1 단계, 이미지 1/3

Kitchen Gourmet WM-6105 Disassembly, Water Heater: 1 단계, 이미지 2/3

Kitchen Gourmet WM-6105 Disassembly, Water Heater: 1 단계, 이미지 3/3

Remove the three rubber feet.
You can pinch them quite hard to pull them out as they are not held in by adhesive.

편집

2 단계

Kitchen Gourmet WM-6105 Disassembly: 2 단계, 이미지 3/3

Remove the 7 12 mm Phillips #1 screws.
The white plastic bar holding two of the screws comes loose once they are unscrewed.

편집

3 단계

Remove the white plastic bar holding the cord.

편집

4 단계

Push the cord through the opening while pulling the base away from the body.

편집

5 단계

Kitchen Gourmet WM-6105 Disassembly: 5 단계, 이미지 3/3

Flip the hot pot so it it right-side-up.

편집

6 단계

Kitchen Gourmet WM-6105 Disassembly: 6 단계, 이미지 3/3

Unscrew the single 8 mm Phillips screw holding the temperature dial in place.

편집

7 단계

Kitchen Gourmet WM-6105 Disassembly: 7 단계, 이미지 3/3

Remove the dial from plastic housing knob.

편집

8 단계

Unscrew the eight 6 mm screws holding in the metal brackets.

편집

9 단계

Kitchen Gourmet WM-6105 Disassembly: 9 단계, 이미지 3/3

Remove the metal brackets.

편집

10 단계

Unscrew the single screw holding down the clamp that connects the thermal switch (black cylinder) and the white wire to the body of the hot pot.

편집

11 단계

Kitchen Gourmet WM-6105 Disassembly: 11 단계, 이미지 3/3

Remove the clamp holding down the thermal switch and white wire.
There is thermal grease between the thermal switch and the metal base of the hot pot. Once the bracket comes off, and the switch comes unattached, you may need to reapply it if you plan to reattach the switch.

편집